Product Name: Ethoxytriethylene Glycol Methacrylate
Chemical Formula: C10H18O6
Synonyms: 2-(2-(2-Methoxyethoxy)ethoxy)ethyl methacrylate, Triethylene glycol monomethacrylate
CAS Number: 2370-63-0
Manufacturer: [Insert Manufacturer Name and Contact Details]
Recommended Use: Raw material for resins, adhesives, coatings, crosslinking in polymerization
Emergency Contact: [24-hour Emergency Tel.]
GHS Classification: Eye Irritant (Category 2A), Skin Sensitizer (Category 1B)
Signal Word: Warning
Hazard Statements: Causes serious eye irritation. May cause an allergic skin reaction.
Precautionary Statements: Wear eye and face protection. Avoid skin contact. Wash hands thoroughly after handling. If in eyes, rinse cautiously with water for several minutes.
Pictograms: Exclamation mark
Chemical Name: Ethoxytriethylene Glycol Methacrylate
Concentration: ≥98%
Impurities: Hydroquinone (inhibitor, <50 ppm), trace monomers and ethers
Other Ingredients: None considered hazardous under normal conditions
Inhalation: Move to fresh air. Support breathing as necessary. Obtain medical attention if symptoms persist.
Skin Contact: Wash immediately and thoroughly with soap and water. Remove contaminated clothing. Seek medical advice if irritation develops or persists.
Eye Contact: Rinse with plenty of water for at least 15 minutes, occasionally lifting eyelids. Remove contact lenses if present and easy. Get prompt medical attention.
Ingestion: Rinse mouth with water. Do not induce vomiting unless directed by medical personnel. Seek medical help if feeling unwell.
Suitable Extinguishing Media: Foam, dry chemical, carbon dioxide, or water spray
Unsuitable Media: Direct stream of water may spread fire
Specific Hazards: Vapors can form explosive mixtures with air. Burning produces carbon monoxide, carbon dioxide, irritant fumes.
Protective Equipment: Full protective gear, self-contained breathing apparatus.
Unusual Hazards: Containers may explode in heat of fire. Avoid inhaling smoke or fumes.
Personal Precautions: Wear protective gloves, goggles, protective clothing. Avoid inhalation of fumes and skin contact.
Spill Response: Ventilate area. Eliminate ignition sources. Use inert absorbent (e.g., sand, vermiculite). Shovel up and place in approved container.
Environmental Precautions: Prevent from entering drains, soil, or surface water.
Cleanup Methods: Wash spill site after material pick-up is complete. Decontaminate area with detergent and water.
Handling: Use only with adequate ventilation. Ground/bond containers and equipment. Avoid inhaling vapors. Avoid contact with skin and eyes.
Storage Conditions: Store in cool, dry, well-ventilated area. Keep container tightly closed and away from sunlight and ignition sources.
Incompatible Materials: Strong oxidizers, acids, bases, peroxides, free radical initiators.
Storage Stability: Add inhibitor such as hydroquinone to prevent polymerization.
Occupational Exposure Limits: Not established for this compound. Observe general chemical safety.
Engineering Controls: Local and/or general exhaust. Eye wash stations and safety showers in work area.
Personal Protective Equipment: Chemical-resistant gloves (nitrile), safety goggles, lab coats or impervious aprons, closed-toe footwear.
Respiratory Protection: Use NIOSH-approved respirator if exposure limits are exceeded or ventilation inadequate.
Hygiene Measures: Wash thoroughly after handling. Do not eat, drink, or smoke during use.
Appearance: Colorless to pale yellow liquid
Odor: Mild, sweet ether-like odor
Odor Threshold: Not determined
pH: Not applicable
Melting Point/Freezing Point: <-50°C
Boiling Point: 112°C at 1 mmHg
Flash Point: >110°C (closed cup)
Evaporation Rate: Not available
Flammability: Flammable liquid
Explosive Limits: Not determined
Vapor Pressure: <1 mmHg at 20°C
Vapor Density: (Air = 1) > 1
Relative Density: 1.07 – 1.09 g/cm³
Solubility: Miscible with water
Partition Coefficient (n-octanol/water): Not available
Auto-ignition Temperature: Not available
Decomposition Temperature: Not determined
Viscosity: 15-20 mPa·s at 25°C
Chemical Stability: Stable with inhibitors under normal conditions.
Polymerization: May occur if heated, exposed to sunlight, or contaminated.
Reactivity: Reacts exothermically with strong oxidizers, acids, bases, initiators.
Incompatible Materials: Organic peroxides, radical initiators, strong acids and bases.
Hazardous Decomposition: Forms carbon oxides, irritating gases.
Routes of Exposure: Inhalation, skin, eyes, ingesting
Acute Effects: May irritate skin, eyes, and respiratory system. Possible skin sensitization with repeated contact.
Chronic Effects: Prolonged exposure can cause dermatitis. No evidence for carcinogenicity based on available data.
LD50 (Oral, Rat): >3,000 mg/kg
LD50 (Dermal, Rabbit): >2,000 mg/kg
Other Information: No adverse reproductive or genetic effects in standard tests observed so far.
Ecotoxicity: Moderately toxic to aquatic life (Fish LC50, 96hr: 50-100 mg/L, Daphnia EC50, 48hr: 50-100 mg/L)
Persistence and Degradability: Not readily biodegradable
Bioaccumulative Potential: Low expected bioaccumulation based on log Pow
Mobility in Soil: Very high water solubility, may leach into groundwater.
Other Adverse Effects: Avoid release to environment; hazardous to aquatic environment in large quantities.
Waste Disposal Methods: Dispose in accordance with local, state, and federal regulations.
Incineration: Allowed at facilities with proper environmental controls.
Packaging: Rinse thoroughly before disposal or recycling.
Precautions: Prevent contamination of surface and groundwater, avoid disposal in sewers.
UN Number: UN3082
UN Proper Shipping Name: Environmentally hazardous substance, liquid, n.o.s. (contains Ethoxytriethylene Glycol Methacrylate)
Transport Hazard Class: 9 (Miscellaneous dangerous substances)
Packing Group: III
Environmental hazards: Marine pollutant
Transport within user's premises: Always transport in original containers, keep sealed and upright, ventilate as needed.
OSHA: Not listed as a hazardous chemical, follow general industry safety standards.
TSCA: Listed on the US Toxic Substances Control Act inventory.
REACH: Registered under EC No. 219-145-8
SARA Title III: Not subject to reporting requirements based on ingredients; always verify based on local regulations.
Other regulations: Product carries hazard labeling for skin/eye irritation and aquatic toxicity.
Workplace labeling: Clearly label all containers with product and hazard information as required.
